Purchased equipment: water tube and fire tube boiler torrent
Location: WUXI China
Telephone: +86 13861509127
E-mail: [email protected]
Contact us for more details about our boilers, solutions and services.

water tube and fire tube boiler torrent
Others

Molten salt heaters use molten potassium nitrate and sodium nitrite as heating media. Molten salt heater will heat the powder salt over the melting point until the viscosity of the molten salt allows circulating pump works, after the whole system is under circulating condition, then feed then into the thermal fluid heater for further circulating rising temperature to make it to be recycling used. Normal media working temperature is 400-550℃, top working temperature could reach 600℃.

Technical advantages

Digitized manufacture

  • The laying-off of steel tube adopts CNC 3D laser cutting machine.
  • The manufacture of square coil tube adopts CNC three-dimensional tube bending machine, no forced shaping.
  • The manufacture of serpentuator adopts serpentuator automatic production line, once-forming.

Long life span

  • The optimized radiation heating surface and convective heating surface, the medium flow is more reasonable, without overheat of the carrier and reduce the life;
  • Convection section: optimize convection heating surface and adopt effective fix and structural support to make its working life longer.
  • Set up effective flue gas partition for convection heating surface and cast partition to make it works longer.

Less fuel consumption

  • Use superior refractory brick to build inside and superior perlite in the middle. Keep the furnace temperature under 50℃ to make the minimization of loss.
  • Furnace adopts double close line coil, which makes heating surface sufficient.

Add Comment

Difference Between Fire Tube Boiler and Water Tube Boile

Water Tube Boiler. It is a boiler in which the water is present inside the tubes and the hot flue gases surrounds the tubes. Since the water is present insides the tubes hence these boilers are called water tube boiler. High pressure steam is produced by these boilers. The pressure of the steam is about 165 bar.

Comparison Between Fire Tube and Water Tube Boil

Comparison between Fire Tube and Water Tube Boiler can be done in 14 aspects. Those aspects are operating pressure, passage of material type in tubes, rate of steam generation, handling of load fluctuation, floor area requirement, efficiency, operator skills, design, maintenance cost are listed below in the tabular form.

Steam System Design and Best Practices Related to Kiln Dryi

Steam System Design and Best Practices Related to Kiln Drying. Typical Simple Boiler Feed Water Tanks SURGE-1 BF-1 OR Vent to Atmosphere Condensate Returns Condensate Return Vent to Atmosphere BF-1 BF-2 To Boiler Keep coil fin and tube area as clean as possible

Dyman Columbia Boiler Company Commercial Boilers : Fre

Competitively-priced, narrow in width easily serviced, this boiler is a modified Scotch, three-pass fire tube design for use as a 15 PSI steam or 30 PSI water unit. The sizes range from 5 BHP to150 BHP, natural gas or LP gas, #2 oil, dual fuel or biogas fired.

Water tube boiler design xls trend: Win Boiler Sim, D

Water tube boiler design xls in Description Condenser Design This software application is intended for use by professional and academics in the engineering industry.

ASME Boiler and Pressure Vessel Co

The boiler and pressure-vessel sections of the BPVC have long miniature boilers; high temperature water boilers, heat recovery steam generators, and certain fired pressure vessels to be used in stationary service; and power ASME’s Boiler and Pressure Vessel Code (BPVC) | 2013.

Water-tube boiler - Wikiped

A slightly more successful adoption was the use of hybrid water-tube / fire-tube systems. As the hottest part of a locomotive boiler is the firebox, it was an effective design to use a water-tube design here and a conventional fire-tube boiler as an economiser (i.e. pre-heater) in the usual position.

Fire-tube boiler - Wikiped

A fire-tube boiler is a type of boiler in which hot gases pass from a fire through one or (many) more tubes running through a sealed container of water. The heat of the gases is transferred through the walls of the tubes by thermal conduction , heating the water and ultimately creating steam .

Fire Tube Gas and Oil Boiler VS Water Tube Gas and Oi

No matter fire tube gas and oil boiler or water tube gas and oil boilers, both of the two boilers have their own advantages and disadvantages. Here we will discuss for better knowing which type is the most appropriate for your project. 14MW Gas fired hot water boiler for heating.

Water-tube and fire-tube boilers - ScienceDire

Compared with the horizontal fire-tube boiler, the vertical water- tube boiler, when steaming at the maximum over a given distance in a given time, is 25 per centum heavier, more bulky and costly; but it requires 25 per centum less weight of coal c~rried in the bunker.

FREE BOILER MANUA

This site is exactly what it says it is - Boiler manuals for free. No registration, just download any boiler manual for free. All you need is the boiler name and make and adobe reader.

text